The need for Alternative Energy Systems to avert China imported Generating sets - COVID-19: Good/Bad?

avatar
(Edited)

image.png
Biogas digester designed by yours truly.

There are indications that some countries who had close allies with China are waking to the reality if the impending crush of their economies if they do not find alternatives to survive without Chinese products.

Nigeria has been a parasitic country when it comes to importation from China over the years. It got worse that even goods made in Nigeria were not patronized by her citizens and some local producers decided to mask their products with the "made in China" label to earn patronage. In fact, the number of known business men who shuttle CHina on monthly basis for clothing, house wares, printing equipment, phones and petrol generators is alarmingly much.

As the economy of China continues to fold up with the spread of Conora Virus, it seemed like a spell was lifted off the eyes of our leaders on why they need to encourage and support local content development. At last, we can be hopeful that an ugly situation can better the economies of some nations.

On March 11, 2020, it sounded funny at first when I saw this newly submitted "BILL FOR AN ACT TO PROHIBIT/BAN THE IMPORTATION/USE OF GENERATING SETS TO CURB THE MENACE OF ENVIRONMENTAL (AIR) POLLUTION AND TO FACILITATE THE DEVELOPMENT OF THE POWER SECTOR" pulished in several local and national dailies - Premiumtimes, Pulse, Guardian and Vanguard. After fully consuming the details of the submissions, I rather did say "maybe COVID-19 happened for our good".

Power supply is one of the biggest challenge we face as a country and we've received lies upon lies by successive administrations as how to better the situation. A typical community receives power supply 2 out of 10 days in a month and everyone is constrained to using power generating sets to power their houses and business premises. In some areas, they rarely see electricity for years.

Currently, I run a fuel generator for 10 hours a day in my Creativity hub and for the past 2 years I've not used electricity. Having been exhausted with such as my monthly power expenses (running cost only) runs into $40. I decided to collaborate with an undergraduate student in my university to design, construct and test-run the Biogas digester above pictured.

Some Technical Information on Biogas and the Designed Machine

The biogas-digester was meant to produce gas using raw poultry waste. Made up of digestion tank and cover, thermometer, gas discharge pipe, gas valve, pressure gauge, material level indicator, solar plate, storage cell, gas tanks, mixer unit with stirrer and support frame, the machine operates at a handling capacity of 0.22m3.

The machine constructed in the Engineering Workshop, University of Uyo was examined using a substrate of concentration ratio of 1:2 and 1:3 waste-water ratios which yielded cooking gas 0.894L/kg and 0.375L/kg of poultry waste in 24 days for the two substrate ratios respectively. Sincerely, at the test level, this machine could reduce cost associated with the purchase of cooking gas and it helps to preserve the environment being an alternative energy system.


Bio-digester on build

While I didn't intend to bug you with technical details of the machines, it was necessary to express how effective a machine which cost about $300 to build could do to home and the environment, yet, we couldn't secure a funding for the the mass production of the Biogas digester because our leaders are in the business of importing costly generating sets from China for our use. The one I currently use costs about $250.

Biogas technology describes the phenomenon where organic matter containing cellulose is fermented in the absence of air (aerobically), combustible gases but majorly (methane) is formed. This technology is one of a number of village-scale technologies that are currently enjoying a certain level of patronage among governments that care about environmental health. Biogas production is often suggested in situations where animal wastes are used as a major source of household energy. We rear animals in Nigeria at subsistence and commercial levels, and such alternative system to power generation would be cheap.

With the increase in wastes generation in our cities and suburbs, a future of bio-fuel utilization can be so beneficial to the ecosystem. Very peculiar about agricultural waste, is the possibility of anaerobic digestion which is a good approach for agricultural waste utilization because it can produce biofuels sufficient for domestic and cottage uses.

I see the coming of Conora Virus as such which will redirect the attention of Nigerians to sustainable power generation especially as our legislators are debating that importation of generating sets shall be viewed as an offence against the law and will attract attract an imprisonment term not less than ten years.

Prohibition/Ban on Importation of generating sets. Any person who- Imports generating sets; or Knowingly sells generating sets shall be guilty of an offence and be liable on conviction to be sentenced to imprisonment for a term not less than ten years.(Source)

COVID-19 as Catalyst to Innovation and Tech Development

I see a new era of building of alternative energy systems such as Solar energy, biogas, across the nations and this would be better for our economy. This is because there will be a reduction in the consumption of fossil fuels which are already so costly for a common Nigerian to afford even for cooking purposes.

I am not in any way happy that the deadly Conora Virus is destroying lives, rather, it sounds good that some economies are already beginning to adjust their priorities to reduce their dependency on China markets and products. It's good because it's starting back here in my own Nigeria.

Occurrences such as this have the potency of enhancing innovations if adequate research and analysis are made by the relevant sectors. It is not time to cry over spilled milk, rather, it's time to look out for solution to build economies that are already falling following Conora outbreak in China.

What are your thoughts and how do you think economies can make adjustments to cope with COVID-19 spread and its effect on Economies?



0
0
0.000
16 comments
avatar

I am happy such an innovation is starting from Nigeria but my concern is will the government support him or tax him expensively.

0
0
0.000
avatar

With their current move, I see a green light on supporting indigenous develpments.

Posted via Steemleo

0
0
0.000
avatar

Hi @uyobong

The Coronavirus is obviously causing so much damage everywhere and is already impacting so many lives - I know mine is. I do wonder though that when the dust settles there will be a few things that have changed in our lives.

Do we need to travel around the world so much? Can we not work from home more and cut down on unessary travel? Do we need such global supply chains with so much reliance on China?

Some will be forced to look for alternatives like you are suggesting is happening in Nigeria in the example you have given. This is a positive side effect of such a horrible situation.

I believe though things will quickly go back to the old ways as people forget the hardships and money starts driving people's decisions again.

0
0
0.000
avatar

Yeah. Thanks @Awah for stopping by. Sometimes all we need is to look at the bright side of life.

Posted using Partiko Android

0
0
0.000
avatar

Agreed. By concentrating on the positives we help save ourselves from insane worry by always seeing the bad things. Sometimes that is hard, like now when we are facing this disaster, as there is just so much bad news. Things will get better again though.

0
0
0.000
avatar

Greetings friend @uyobong.

Great demonstration of Nigerian ingenuity and creativity.
I have seen several Gas generators based on animal waste. This prototype seems quite functional.

As you said well, these moments of calamity that humanity is experiencing can serve as motivating agents to begin to value and promote the internal market and national production.

It should not only serve to deal with dependence on products from China or the spread of COVID-19. But to prepare us for future situations. May these times serve as a reflection and that the prevention and self-sustainability of nations is a priority for the governments of the world.

Your friend, Juan.

0
0
0.000
avatar

May these times serve as a reflection and that the prevention and self-sustainability of nations is a priority for the governments of the world.

Those lines are my prayers.

Thanks Juan.

Posted via Steemleo

0
0
0.000
avatar

This is such a great idea and I really hope that the government supports this great innovation and if it is accepted, I am sure you will be a big man (smiles).

0
0
0.000
avatar


This post has been voted on by the SteemSTEM curation team and voting trail. It is elligible for support from @curie and @minnowbooster.

If you appreciate the work we are doing, then consider supporting our witness @stem.witness. Additional witness support to the curie witness would be appreciated as well.

For additional information please join us on the SteemSTEM discord and to get to know the rest of the community!

Please consider using the steemstem.io app and/or including @steemstem in the list of beneficiaries of this post. This could yield a stronger support from SteemSTEM.

0
0
0.000